Loren Data's SAM Daily™

FBO DAILY ISSUE OF SEPTEMBER 03, 2006 FBO #1742
SOLICITATION NOTICE

45 -- 20 yard, rear load Garbage Truck

Notice Date

9/1/2006
 

Notice Type

Solicitation Notice
 

Contracting Office

PWR - SEKI Sequoia/Kings Canyon NP Ash Mountain Supply Center 47050 Generals Hiway Three Rivers CA 93271
 

ZIP Code

93271
 

Solicitation Number

Q8564060062
 

Response Due

10/2/2006
 

Archive Date

9/1/2007
 

Small Business Set-Aside

Total Small Business
 

Description

This is a combined synopsis/solicitation for commercial items prepared in accordance with Federal Acquisition Regulation (FAR) 12.6, as supplemented with additional information included in this notice. This announcement constitutes the only solicitation; quotations are being requested and a written solicitation will not be issued. The solicitation number is Q8564060062 and is issued as a Request for Quotations (RFQ) for a garbage truck. This solicitation document and incorporated provisions and clauses are those in effect through Federal Acquisition Circular 2005-12, dated August 5, 2006. This solicitation is set-aside for small business. The North American Standard Industrial Classifications System Code is 336211 and the small business size is 1000 employees. ----SPECIFICATIONS--- ** All specifications are "Equivalent To" and may be substituted with equal or better except for those items marked with a [X]. No substitution will be accepted when items are marked [X] unless a written approval is received prior to bid closing date of October 2, 2006. TRUCK SPECIFICATIONS: - Peterbilt model 320 - [X] Cab-over - [X] maximum length 20 feet - [X] single rear axle - [X] additional lift axle, Single 12,000 lb Pusher, self-steering liftable. Includes lift switch in dash, gauge in dash, regulator on suspension cross member, and (1) air tank. Also to include 52" pusher axle spacing from centerline of forward Drive Axle. - [X] meet all California Registry requirements (licensing will be taken care of by the National Park Service) FRAME & EQUIPMENT: - 10-3/4in Steel Rails, Steel Xmbrs, To 305in 3/8in Rail Thickness 10.75 X 3.5 X .38 RBM = 1,960,000 4-PIECE NYLON INSERT FRAME FASTENERS CLASS 10.9 BOLTS 3-PIECE C-CHANNEL XMBR W/CAST GUSSETS CHASSIS HOSE AND WIRING BUNDLES CONVENIENTLY ROUTED THROUGH GUSSETS - EOF Square without Xmbr for use with body builder installed cross-member - Omit Rear Mud flaps and Hangers - Front Wheel Mud flaps - 2) Front Tow Eyes with Pins FRONT AXLE AND EQUIPMENT: - [X] Dana Spicer E1462I 14,600 lb Dana Spicer ES cam brakes, 11-1/4in bolt circle. FACTORY FRONT AXLE ALIGNMENT OUTBOARD MOUNTED BRAKE DRUMS ZERK FITTINGS ON TIE ROD ENDS, KING PINS AND DRAGLINK BALL JOINTS - Split Progressive Springs 16,000 lbs Use with 14,600 lb front axles. - Power Steering TRW TAS85 Glidekote splines on steering shaft - PHP10 Alum LMS Hubs, Cast Drums, 16.5x5 Brakes 13,200 and 14,600 lb front axles. Includes Dana Spicer EES420 brake linings, non-asbestos. - Chicago Rawhide Scotseal Plus XL Oil Seals - Haldex/Dana Auto Slack Adjusters REAR AXLE AND EQUIPMENT: - [X] Dana Spicer S23-170D, 23,000 lb WITH WHEEL DIFFERENTIAL LOCK LASER FACTORY AXLE ALIGNMENT ACCURATE TO .030 OF AN INCH MAGNETIC REAR AXLE OIL DRAIN PLUG OUTBOARD MOUNTED BRAKE DRUMS - PHP10 Alum LMS Hubs, Cast Drums, 16.5x7 Brakes 23,000 lb maximum, single axle, Dana Spicer ES brakes. - PHP10 Alum LMS Hubs, Cast Drums, 15x4 Brakes Single Self-Steering Tag/Pusher Axle - MGM TR 3030in Parking Brakes, Single Axle -Haldex/Dana Auto Slack Adjusters, Single Axle -Haldex/Dana Auto Slack Adjusters, Single T/P -Chicago Rawhide Scotseal Plus XL Oil Seals, Single -Chicago Rawhide Scotseal Plus XL Oil Seals, T/P Single - [X] Dana Spicer ES 16.5x7 Cam Brakes, Refuse 17,000-23,000 lb rear axle, Dana Spicer ES non-asbestos brake linings, gussetted cam brackets, cast brake spiders. - Bendix 4S4M ABS, SBM Valve ABS-6 - Synthetic Axle Lubricant, All Axles - [X] Ratio 5.57 Rear Axle (5.38 will also be acceptable) - Reyco 102 23,000 lb Single Drive - Omit Suspension Insert ENGINE AND ENGINE EQUIPMENT: - [X] Cummins,ISM320V 320/2100 320@1500 1150@1200 Includes alum flywheel housing. CHEVRON DELCO MULTIGRADE ENGINE OIL, SAE 15W40 MAGNETIC ENGINE OIL DRAIN PLUG N20300 P029 No....Idle Shutdown Enable N20320 P015 Yes...Engine Protection Shutdown N20380 P001 70....Max Speed in Top Gear N20400 P059 65....Maximum Cruise Speed N20440 P030 0.....Idle Shutdown Timer -Turbo Heat Shield -Delco Remy 130 Amp. Alternator 22 SI -Delco Remy 12V Starter KEY IGNITION/PUSH BUTTON START SWITCH WEATHER PACK SILICONE SEALED ELECTRICAL CHASSIS CONNECTORS 12 VOLT SYSTEM W/CIRCUIT PROTECTION WIRES NUMBERED EVERY 4 INCHES OR LESS MAINTENANCE FREE 12V BATTERIES STRANDED COPPER BATTERY CABLES DOUBLE AUGHT (00) OR LARGER -3 PACCAR Premium 12V Dual Purpose Batt 2100 CCA Threaded Stud Type Terminal - Horton Fan Clutch - ISM DriveMaster - 18.7 CFM Air Compressor (Furnished on Engine) - [X] C-Brake by Jacobs - ISM (exhaust brake not acceptable) - Spin-on Fuel Water Sep-ISM Frm Mtd - Spin-on Water Filter Engine Mntd - ISM,ISX - Cummins Engine Protection Shutdown Includes oil pressure, oil temperature, coolant temperature, and intake manifold temperature. - High Efficiency Cooling System - Silicone Radiator Hoses Includes Constant Torque Clamps - Bug screen--Removable Type Rad Mtd Additional clips at bottom of bug screen. - Wing Nut Style Mounted Grille -Dnldsn 16in FVG Air Cleaner Horizontal Mounted ISM/CG (FVG16-0619) Dual Element/Dual Stage MOLDED RUBBER AIR INTAKE CONNECTIONS WITH LINED STAINLESS STEEL CLAMPS - Single Vertical Exhaust R/H STAINLESS STEEL FLEX TUBING & CLAMPS - Single Exhaust Guard Stainless Steel TRANSMISSION AND CLUTCH: - [X] Allison 4500 RDS-P Rugged Duty Service Includes Rear Trans Support and TranSynd Transmission Fluid. (Suited for vehicles operating on/off highway and/or requiring PTO operation) MAGNETIC TRANSMISSION OIL DRAIN PLUG - [X] 1710 HD Driveline With Single Midship Bearing HALF ROUND END YOKES W/ZERK FITTINGS COATED DRIVESHAFT SPLINES - Water-to-Oil Heat Exchange Allison Transmission -Allison RDS Auto Neutral `AK` Single Steer LH or RH plumbed to Flip Valve to actuate service brakes if Code 4540940 is specified. - Allison 6-Speed Configuration - Wide Ratio Gears Allison 4500 Trans only AIR AND TRAILER EQUIPMENT: - Bendix AD-IP EP Air Dryer with Heater Extended Purge (for use with higher consumption applications). Includes Single-Bolt Desiccant Cartridge and wet Air Tank. - Nylon Chassis Hose BRAIDED CHASSIS HARNESS COVER RUBBER-LINED CLAMPS ALONG FRAME RAIL TEFLON-LINED, STAINLESS STEEL BRAIDED COMPRESSOR DISCHARGE HOSE -Steel Painted Air Tanks TIRES AND WHEELS: - [X] FF: 16ply 12R22.5 R250F - [X] RR: 16ply 11R22.5 M711 - FF: Accur 29039pw Plt 22.5x9.00 Stl Whl Pilot Mount - RR: Accur 28408 Plt 22.5x8.25 Stl Whl Pilot Mount, Two Hand Holes - Code-rear Rim Qty 04 - TP: (2) BR 14ply 295/75R22.5 R287 For single self-steering tag/pusher axles - TP: (2) Accur 28408 Plt 22.5x8.25 Stl Whl For single self-steering tag/pusher axles, Pilot Mount FUEL TANKS: -23in Aluminum 70 Gallon Fuel Tank RH BOC PADDLE HANDLE FILLER CAP WITH THREADLESS FILLER NECK WIRE BRAID FUEL LINE -Location RH BOC 70 Gallon - Fuel Cooler BATTERY BOX AND BUMPER: - Steel Space Saver Battery Box LH Back Of Cab - Steel Bumper Channel Painted CAB AND EQUIPMENT: - 53in LCF Cab LH Drive Includes steel frames with alum and fiberglass panels, all alum doors, dual door stops, door locks, tinted safety glass thru-out, cab and door mounted entry grab handles, 53 degree hydraulic tilt, stainless steel grille, dual rear cab fenders, service module BOC (cab tilt pump, oil fill and dipstick, coolant fill and check, fluid fill and dipstick for auto trans), door mounted armrests, full insulation, rubber floor mats, engine tunnel mounted control console, removable instrument panel with speedometer message center, cigar lighter and ashtray, view window in RH door, 18in step height on each side, extended metal step with additional grab handle LH/RH. IGNITION AND DOORS KEYED ALIKE FULL LENGTH PIANO TYPE STAINLESS STEEL DOOR HINGES AND PINS - UltraRide LowBack Fabric Air Driver Seat - Talladega 905 MidBack Fabric Air Passenger Seat - 3-Point Safety Belt-Driver & Pass - Gray Interior Color Includes ABS gray headliner & rear cab panel, gray vinyl engine tunnel cover. - (2) Inside Sun visors - Engine Tunnel Cover Padded Vinyl - 17in Black Steering Wheel (For use with Code 6501000 LH Drive or 6501010 RH Drive only) - Rear Window Back of Cab Dark Tint 18.5in X 54in - View Window in RH Door - Roll-Down Windows RH and LH Doors - Combo Fresh Air Heater/Air Conditioner with radiator mounted condenser, dedicated side window defrosters (not Models 320 or 335), Bi-Level Heater/Defroster Controls, and 54,500 BTU/HR. - Heater Water Shutoff Ball Valves 1/4 turn, Cab/Sleeper - Silicone Heater Hoses - Stainless Steel Mirrors 7x16 with Heat Element Prutsman MDP716S - (2) Convex 8 Inch SS Mirror Center mounted under mirror bracket. - (1) Air Horn 24.5in Chrome - Round w/Horn Shield DUAL ELECTRIC HOR - Concert Class Audio System with CD DayCab only. Includes AM/FM/WB frequencies, (2) cab mounted speakers, and antenna. - AM/FM/WB Radio - Electric Windshield Wipers with Intermittent Feature - 5 Lb 3a:40bc Fire Extinguisher-Shipped Loose - Triangle Reflector Kit Shipped Loose - Ecco DS-1500 Reverse Motion Sensor Use with backup alarm. - Backup Alarm (112dB) - Oil Temp Gauge Trans - Main Allison Transmission - Water Temp Gauge - Oil Pressure Gauge - Engine - Air Application Gauge - (2) Air Pressure Gauges Primary and Secondary - Fuel Level Gauge - Speedo Dixson Elec 0-80 MPH, 0-130 KPH without Odometer - Tach Dixson Elec 0-3000 RPM - Voltmeter - Headlights Dual Rect Halogen - Marker Lights (7) Standard ICC - Directionals Front Surface Mounted above headlights with side-mounted turn signals behind doors. PAINT: - [X] Paint Color Selection within Paint Deck, 6284A yellow COMPACTOR: - [x] Heil [x] Formula 4000 [x] 20 Yard [x] Rear bin lift bar (cable lift not acceptable) [x] Color 6284A yellow [X] = Substitutes only by written approval The price is to include all charges for set-up, delivery, and other fees. Delivery to be on or before March 30, 2007 at Sequoia National Park, Ash Mountain Machine Shop, 47050 Generals Hwy, Three Rivers CA, 93271. The technical contact person for this item is: Jack Fiscus at 559-565-3146 and the administrative contact is Fred Picavet 559-565-3180. Offerors/Bidders/Quoters must review and comply with the FAR Provisions or Clauses which apply to this solicitation. This information is available on the Internet at http://www.arnet.gov/far. The following clauses or provisions are specifically referenced and are required in the response to this solicitation: 52.212-1, INSTRUCTIONS TO OFFERORS-COMMERCIAL ITEMS; 52.212-2, EVALUATION-COMMERCIAL ITEMS - Evaluation factors include The government will evaluation on [a] price; [b] delivery; [c] warranty; [d] meeting specifications and; [e] availability of local service and parts for the truck and compactor. 52.212-3, OFFEROR REPRESENTATIONS AND CERTIFICATIONS-COMMERCIAL ITEMS, a completed copy of the provision at 52.213-3 must be submitted with the bid / offer, or you can register your reps and certs online at http://orca.bpn.gov; 52.212-4, CONTRACT TERMS AND CONDITIONS-COMMERCIAL ITEMS applies to this acquisition; 52.212-5, CONTRACT TERMS AND CONDITIONS REQUIRED TO IMPLEMENT STATUTES OR EXECUTIVE ORDERS-COMMERCIAL ITEMS, applies to this acquisition including, 52.233-3 Protests after award, and 52.333-4 Applicable Law for Breach of Contract Claim, and, the following paragraph (b) clauses added: 52.222-3 Convict Labor, 52.222-19 Child Labor - Cooperation with Authorities and Remedies, 52.222-21 Prohibition of Segregated Facilities (Feb 1999), 52.222-26 Equal Opportunity (E.O. 11246), 52.222-35 Affirmative Action for Disabled Veterans and Veterans of the Vietnam Era; 52.222-37 Employment Reports on Disabled Veterans and Veterans of the Vietnam Era; 52.225-3 Buy American Act-North American Free Trade Agreement-Israeli Trade Act-Balance of Payments Program with alternate 1; 52.225-13 Restrictions on Certain Foreign Purchases, 52232-33 Payment by Electronic funds Transfer - Central Contractor Registration. VENDOR EVALUATION: The government will evaluation on [a] price; [b] delivery; [c] warranty; [d] meeting specifications and; [e] availability of local service and parts for the truck and compactor. If you cannot meet the exact delivery dates mentioned above include closes dates you will be able to make the delivery. QUOTES ARE DUE: Quotes are due for this combined synopsis/solicitation on October 2, 2006 at 4:00 PM Pacific Daylight time and shall be delivered by the specified time to the National Park Service, Sequoia and Kings Canyon National Park, 47050 Generals Hwy, Three Rivers, CA 93271, ATTN Contracting Office: RFQ #Q8564060062. Facsimile Quotations are acceptable with all required documentation at 559-565-3700. No oral quotations will be accepted. Biders must furnish the company name, DUNS number, TIN Number, address, phone and fax number, email address if available, official point of contact, and Certifications and Representations as required by clause 52.212-3 above. All Quotes must be manually signed by authorized company official. All questions regarding this solicitation should be faxed to Fred Picavet, 559-565-3700. Email questions are acceptable to fred_picavet@nps.gov. END OF COMBINED SYNOPSIS SOLICITATION.
 

Web Link

Please click here to view more details.
(http://ideasec.nbc.gov/j2ee/announcementdetail.jsp?serverId=NP144302&objId=2279562)
 

Place of Performance

Address: Sequoia and Kings Canyon National Park 47050 Generals Hwy Three Rivers, CA 93271

Zip Code: 93271

Country: usa
 

Record

SN01132885-W 20060903/060901221408 (fbodaily.com)
 

Source

FedBizOpps Link to This Notice
(may not be valid after Archive Date)

---

| FSG Index  |  This Issue's Index  |  Today's FBO Daily Index Page |