SOLICITATION NOTICE
20 -- DRYDOCK FOR CGC SKIPJACK AND CGC MANTA
- Notice Date
- 9/19/2012
- Notice Type
- Presolicitation
- NAICS
- 336611
— Ship Building and Repairing
- Contracting Office
- Department of Homeland Security, United States Coast Guard (USCG), USCG Surface Forces Logistics Center (SFLC) Procurement Branch 1, 300 East Main Street, Suite 600, Norfolk, Virginia, 23510-9102, United States
- ZIP Code
- 23510-9102
- Solicitation Number
- HSCG80-13-R-P45033
- Point of Contact
- Nancy M Brinkman, Phone: 757-628-4579, Louis J Romano, Phone: (757)628-4651
- E-Mail Address
-
Nancy.M.Brinkman@uscg.mil, louis.j.romano@uscg.mil
(Nancy.M.Brinkman@uscg.mil, louis.j.romano@uscg.mil)
- Small Business Set-Aside
- Total Small Business
- Description
- PRE-SOLICITATION: The United States Coast Guard, Surface Forces Logistics Center, Detachment Norfolk VA, intends to issue a Commercial Request for Proposal (RFP) for Dry-dock and repairs to the CGC SKIPJACK (WPB-87353) and CGC MANTA (WPB-87320) both 87-Foot Patrol Boats. The NAICS Code is 336611. The Coast Guard intends to conduct the procurement in accordance with Federal Acquisition Regulation (FAR) Part 12, Acquisition of Commercial Items, and FAR Part 15, Contracting by Negotiation for Certain Commercial Items. The simplified acquisition will be issued as a Small Business Set-Aside. Request for Proposals (RFP) will be issued on or about September 19, 2012. The acquisition is to perform drydock and repairs to the CGC SKIPJACK and CGC MANTA. The vessels are geographically restricted to a facility located within an area no greater than 500 nautical miles one-way and 1000 nautical miles roundtrip from Galveston, TX. The Period of performance for CGC SKIPJACK is FORTY-FIVE (45) calendar days from 30 JAN through 15 March 2013. The Period of performance for CGC MANTA is FORTY-FIVE (45) calendar days from 1 MAY through 14 JUN 2013. All work will be performed at the contractor's facility within the geographical restriction as stated above. The solicitation will be issued electronically via the Federal Business Opportunity web page at http://www.fedbizopps.gov. It is incumbent upon contractors to monitor the FEDBIZOPS web page for the RFP release and all subsequent amendments. Hard copies of the specification and solicitation will not be issued. The scope of the acquisition is for the overhauling, renewing and repairing of various items aboard the CGC SKIPJACK and CGC MANTA. This work may include, but is not limited to: 1. Perform Ultrasonic Thickness Measurements 2. Perform Ultrasonic Thickness Measurements 3. Bilge Surfaces (Engine Room), Preserve (Partial) 4. Bilge Surfaces (Mess Deck), Preserve (Partial) 5. Dirty Oil Tank, Clean and Inspect 6. Oily Water Tank, Clean and Inspect 7. Tanks (MP Fuel Service), Clean and Inspect 8. Pilothouse Deck (Aluminum), Inspect, Preserve, and Renew Electrical Matting 9. Depth Sounder, Capastic Fairing, Renew 10. Main Engine/Reduction Gear, Realign 11. Propulsion Shafts, Remove, Inspect, and Reinstall 12. Propulsion Shaft, Repair 13. Propulsion Shaft, Straighten 14. Intermediate Water-Lubricated Propulsion Shaft Bearing, Renew 15. Aft Water-Lubricated Propulsion Shaft Bearing, Renew 16. Intermediate Bearing Carrier, Renew 17. Aft Bearing Carrier, Renew 18. Stern Tube, Interior Surfaces, Preserve 100% 19. Stern Tube, Interior Surfaces, Repair 20. Propellers, Remove, Inspect, and Reinstall 21. Propeller, Minor Reconditioning and Repairs, Perform 22. Fathometer Transducer, Renew 23. Speed Log, Skin Valve Assembly, Clean and Inspect 24. Sea Water System (Sea Valves, Strainers, Piping), Clean, Inspect, and Repair 25. Rudder Assemblies, Remove, Inspect and Reinstall 26. RHIB Notch Skid Pads, Inspect 27. RHIB Notch Skid Pad Studs, Renew 28. Stern Launch Door, Remove, Inspect and Reinstall 29. Grew Water Holding Tank, Clean and Inspect 30. Sewage Holding Tank, Clean and Inspect 31. Grey Water Piping, Clean and Flush 32. Sewage Piping, Clean and Flush 33. U/W Body, Preserve 100% 34. Cathodic Protection/Zincs, Renew 35. Drydocking 36. 36. Temporary Services, Provide 37. Telephone Service, Provide 38. Ventilation System, Engine Room Supply and Exhaust Fan Assemblies, Clean and Inspect, Preserve 39. Main Diesel Engine, Renew 40. Ship Service Diesel Generator, Renew 41. Mast, Preserve 100% A CD-ROM containing all applicable drawings will be sent via U.S. mail, if requested. Send all requests to Nancy.M.Brinkman@uscg.mil The CD-ROM sets are available of all cutters and will be free of charge to contractors upon request. The CD-ROM(s) contain WINDOWS compliant raster/vector formats (e.g.*.DWF, etc). Proposals are due on or about October 19, 2012 at 10:00 a.m. Eastern Standard Time and may be sent via: Email: nancy.m.brinkman@uscg.mil or mailed to US Coast Guard SFLC/C&P1/PBPL Attn: Nancy Brinkman 300 East Main Street, Suite 600 Norfolk, VA 23510-9102
- Web Link
-
FBO.gov Permalink
(https://www.fbo.gov/spg/DHS/USCG/COUSCGMLCA/HSCG80-13-R-P45033/listing.html)
- Place of Performance
- Address: CONTRACTOR'S FACILITY WITHIN THE GEO-GRAPHICAL RESTRICTION, United States
- Record
- SN02889404-W 20120921/120920000233-ff97d3ed75c5ad949c7bec456e7507af (fbodaily.com)
- Source
-
FedBizOpps Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |